Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB026  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Address  1560 STATE RT. 50 NORTH
Owner or Operator   JOE'S CATERING, INC. City   BOURBONNAIS Zip Code   60914
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
X
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
X
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
  
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
X
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
  
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
X
1
 Installed, maintained
*41
X
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
X
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
X
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
X
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   QUAT 200-400 ppm                   Dishwasher Temperature   120-140F °F or label
Food Temperatures:   LASAGNA 39,NOODLES 44, SALMON 40, PORK CHOP 40, RAW HAMBURGER 38, CHEESE 36, RAW SAUSAGE 37, PEPPERONI 41, STUFFED MUSHROOM 38, SHRIMP 35
 
General Comments
HACCP CONCEPTS DISCUSSED: KEEP ALL CHEMICALS STORED AWAY FROM FOOD AND FOOD CONTACT SURFACES. ALL EMPLOYEE'S HAVE A FOOD HANDLER'S LICENSE. 
Report and Instructions Received By   ANTONIO AVALOS SR. /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  11/02/2016 Time In  2:25 PM Time Out  3:55 PM Sanitation Score  76 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  85  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB026  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Address  1560 STATE RT. 50 NORTH
Owner or Operator   JOE'S CATERING, INC. City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*31  Observed the following hand sink(s) to be inaccessible: Metal covering blocking hand sink. Provide for all handsinks to be accessible at all times to assure that proper handwashing occurs. Chef will remove metal. 750.1120 Immediate/Onsite
*41  Observed the following chemical(s) to be improperly stored: Butane fuel was stored on shelf by hot sauce. Provide for all food, equipment, utensils, and single service articles to be stored either above or completely separate for all toxic chemicals. 750.1310 Immediate/Onsite
2  Observed the following food products to have improper/no labeling information. There is no time & date on cooked foods in the walk-in cooler. Provide for all foods to have proper labeling information. 750.100 Next Inspection
8  Observed the following food products to be improperly stored. 1. Found boxes of food on the floor in the walk-in freezer. 2. Make sure all foods are covered in the walk-in cooler. Provide for all food products to be stored at least six inches off of the floor. 750.130 Next Inspection
14  Observed the following improper food contact surfaces. 1. Cutting boards have a lot of knife grooves in them on prep line.2. Rust found on some of the shelves in the walk-in cooler. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbent, corrosive resistant, and light colored. 750.650 Next Inspection
15  Observed the following improper non-food contact surfaces. 1. Seal gasket is torn on True refrigerator. 2. Found torn tin foil under grill and on back shelves by pizza maker. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbent, corrosive resistant, and light colored. 750.650 Next Inspection
21  Observed the following wiping cloth(s) to be improperly stored: Soiled wiping cloths found on prep tables. Provide for all wiping cloths to be stored completely submerged in an approved sanitizer solution while not being used. 750.820 Next Inspection
22  Observed the following food contact surfaces to be unclean. Cutting boards have a lot of food stains in them. Clean and maintain. 750.800 Next Inspection
23  Observed the following contact surfaces to be unclean. 1. Seal gasket on True refrigerator & reach-in coolers have food debris in them. 2. Interior of fryer has grease & debris in it. Clean and maintain. 750.800 Next Inspection
29  Observed the following plumbing to be improperly installed or maintained: There is a leak in the plumbing under hand sink in employee's women's restroom. Provide for all plumbing to be sized, installed, and maintained in accordance with applicable provisions of the Illinois State Plumbing Code. All Plumbing modifications and/ or upgrades will be required to be permitted to inspected by the local plumbing inspector. 750.1060 Next Inspection
32  Observed no soap and/or paper towels at the following hand sink(s). There is no soap at hand sink in Men's restroom. Provide for all handsinks to have supply of soap and paper towels to assure that proper handwashing occurs. 750.1120 Next Inspection
33  Observed dumpster lids were open. Keep shut when not in use. 750.1140 Next Inspection
34  Observed the dumpster area to be unclean. Debris found around dumpster. Provide for the dumpster area to be kept clean so as to not be an attractive nuisance. 750.1140 Next Inspection
37  Observed the following wall/ceilings, and attached equipment to be unclean: 1. Wall by fryer has grease & food debris on it. 2. Fan guards in the walk-in freezer has dust on them. Provide for all walls, ceilings, and attached equipment to be in a clean condition. 750.1220 Next Inspection
     
     
     
     
Report and Instructions Received By   ANTONIO AVALOS SR. /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  11/02/2016 Time In  2:25 PM Time Out  3:55 PM Sanitation Score  76 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  85  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB026  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Address  1560 STATE RT. 50 NORTH
Owner or Operator   JOE'S CATERING, INC. City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
Report and Instructions Received By   ANTONIO AVALOS SR. /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  11/02/2016 Time In  2:25 PM Time Out  3:55 PM Sanitation Score  76 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  85